Lift stops after about 30 min time

[Kurtis01]

Ok all new, hyd pump filter and fluid. After about 20 to 30 min time lift gets where it whines when i lift it. What could be my problem please.

 

[ShaunRH]

What machine is it?
How is it being used?
Is the fluid foamy when you are having problems?

 

[85Hokie]

Ok all new, hyd pump filter and fluid. After about 20 to 30 min time lift gets where it whines when i lift it. What could be my problem please.

What fluid did you place back in? weight of fluid? and IS there enough fluid there?

 

[Kurtis01]

Sorry was not thinking right it is a 1984 L245DT used tractor supply hyd fluid the one that everybody says they use.Super trac 303 hyd fluid. It is full and yes it looks foamy when i check the level. thanks

 

[D2Cat]

Sounds like hyd. system is sucking air somewhere. Check the hose that is clamped near the hyd. filter.

 

[Kurtis01]

Sounds like hyd. system is sucking air somewhere. Check the hose that is clamped near the hyd. filter.

what all places should have a closed system so it can not suck air? When i got the tractor a couple months the pump and the housing under the seat had been off but they did not put gaskets back on if it takes them some has blue gasket gue around but no gasket but that should hurt with sucking air cause it draws fluid from the bottom. If im wrong please tell me. Thanks again

 

[007kubotaguy]

Hello
The first thing to check is the suction screen . You will need to drain the hydraulic system first. The screen is
Located under the left foot rest. It's behind a cap that is held in with two bolts with 12 MM heads. Remove the cap and you should have a spring with a filter behind it. Remove the screen and clean. Good luck Lance